Boeing ‘inappropriately coached’ pilots in 737 MAX testing: US Senate report

Reading Time: 3 minutes

Boeing officials” inappropriately coached” test pilots during recertification efforts after two fatal 737 MAX crashes killed 346 people, according to a lengthy congressional report released on Friday.

The report from the Senate Commerce Committee Republican staff raised questions about testing in 2020 of a key safety system known as MCAS tied to both fatal crashes was contrary to proper protocol.

The committee concluded that Federal Aviation Administration (FAA) and Boeing officials “had established a pre-determined outcome to reaffirm a long-held human factor assumption related to pilot reaction time.

It appears, in this instance, FAA and Boeing were attempting to cover up important information that may have contributed to the 737 MAX tragedies.”

Boeing faces safety questions over safety after Ethiopian crash:

The report citing a whistle-blower who alleged Boeing officials encouraged test pilots to “remember, get right on that pickle switch” prior to the exercise that resulted in pilot reaction in approximately four seconds, while another pilot in as separate test reacted in approximately 16 seconds. The account was corroborated during an FAA staff interview, the committee added.

Numerous reports have found Boeing failed to adequately consider how pilots respond to cockpit emergencies in its development of the 737 MAX.

Boeing said on Friday it takes “seriously the committee’s findings and will continue to review the report in full.”

The FAA said Friday it was “carefully reviewing the document, which the committee acknowledges contains a number of unsubstantiated allegations.”

The agency added it is “confident that the safety issues that played a role in the tragic (737 MAX) accidents involving Lion Air Flight 610 and Ethiopian Airlines Flight 302 have been addressed through the design changes required and independently approved by the FAA and its partners.”

Senate Commerce Committee Chairperson Roger Wicker said the report “details a number of significant examples of lapses in aviation safety oversight and failed leadership in the FAA.”

The committee also said: “multiple independent whistle-blowers contacted the committee to allege FAA senior management was complicit in determining the 737 MAX training certification level prior to any evaluation.”

Boeing resisted requiring simulator training for pilots before operating the 737 MAX but reversed course in January.

The report also noted Southwest Airlines was able to operate more than 150 000 flights carrying 17.2 million passengers on jets without confirmation that required maintenance had been completed.

The Senate report said the Southwest flights “put millions of passengers at potential risk.” Southwest said Friday it was aware of the report and added “we do not tolerate any relaxing of standards that govern ultimate safety across our operation.”

Boeing still faces an ongoing criminal probe into the MAX. The committee said its review was “constrained due to the continued criminal investigation.”

In November, the FAA approved the 737 MAX’s return to service and flights have resumed in Brazil. The first US 737 MAX commercial flight with paying passengers is set for 29 December.

In November, the Senate committee unanimously a bill to reform how FAA certifies new airplanes and grant new protections for whistle-blowers, among other reforms, while the US House of Representatives unanimously passed a similar bill.